-
Engine
All
internal lubricated parts including: pistons;
piston rings and pins; crankshaft and main bearings;
rod bearings;timing chain; timing gears; rocker
arms; cover; valves; valve springs, guides and
seats; valve pushrods; lifters; camshaft and
bearings; cylinder heads; cylinder barrels;
intake manifold; exhaust manifold; flywheel
and ring gear; harmonic balancer; oil pan; oil
pump; engine mounts; distributer housing, shaft
and bearings; oil cooler housing; oil filter
housing; turbocharger housing and all internal
parts; turbocharger wastegate actuator; seals
and gaskets.
-
Diesel
Engine
All
parts included in the engine section including
head bolts; air intake housing; flywheel housing
and front covers.
-
Lubricating
System
Oil injection pump,
drive gear and/or shaft; oil tank; oil cap;
oil level sensor; warning horn; oil lines; complete
oil injection metering system; oil injection
check valves; seals and gaskets.
-
Cooling
System
engine
water pump (excluding outboard impellers); coolant
circulating pump; heat exchangers; seals and
gaskets.
-
Fuel
System
Fuel
distributers; fuel injection pump; fuel injectors;
control unit; flame arrestor; fuel pump; carburetor
body; diaphragm.
-
Transmission
All
internally lubricated parts within the transmission
case; transmission mounts; oil pan; gears; bearings;
bearing carriers; clutch and thrust plates;
clutch drums, shift bands; hydraulic pumps;
valve bodies; seals and gaskets.
-
V-Drive
All
internally lubricated parts within the V-Drive
case; case; bevel gears; bearings; thrust bearings;
shafts; shims and bearing carriers; seals and
gaskets.
-
Jet-Drive
All
internally lubricated parts in the pump housing;
Housing; Seals and Gaskets
-
Stern
Drive/Upper & Lower Units
All
internally lubricated parts contained within
the gear case and upper housing.
-
Steering
Steering
control helm assembly; control rack and pinion
and yoke assembly; power steering pump; hydraulic
steering head; hydraulic steering lines and
control valves; power cylinder assembly; steering
wheel and coupling; steering cable; seals and
gaskets.
-
Controls
Shift and throttle
control cables; ignition switch; neutral start
switch; throttle cam lever.
-
Electrical
Alternator;
stator; starter; powertilt motor; voltage regulator;
regulator rectifier; engine wiring harness;
engine terminal blocks; choke solenoid; starter
drive; ignition coil; starter solenoid; switch
box; ignition module; trigger.
-
Power
Trim & Tilt
Spring
sending unit; oil pump; pump relief valve; spring;
o-ring; trim cylinder; motor; solenoids; wiring
harness; manual release valve; hydraulic pump;
reverse lock valve; limit switches; master switches;
seals and gaskets.
